How is a diamond condition fixed? - Correct Answers By pulling the damage for length. Diamond is a
length condition.
When measuring a unibody vehicle, it is discovered that the left front rail is 111mm from spec in width.
What condition is this? - Correct Answers Width is calculated from the center out, so a value of -111mm
on the left rail shows sway to the right and in toward centerline.
A collision damaged vehicle is discovered to be down in height at opposite end of the center section. -
Correct Answers Twist condition.
When diagnosing the damage to a full frame assembly on a sport utility vehicle, it is determined that the
left side frame rail is higher than the right side frame rail. Technician A says the damaged state is known
as a twist condition. Technician B says a sway condition exists. Who is right? - Correct Answers Tech A.
When a frame rail's relationship to the vehicle centerline is changed, such as pushed either to the left or
right, the condition is known as sway. "Twist" is referred as the condition of the frame when entire
sections are driven higher or lower than the opposite side.
Metal fillers contain different ingredients that provide fillers with special properties. - Correct Answers
Fiberglass offers more resistance to moisture
HSLA - Correct Answers High Strength Low Alloy
When replacing the floor pan in the trunk area, what joint should be used to join the new pan to the
existing floor? - Correct Answers An overlap joint
When acoustical foam is removed during the repair: - Correct Answers It must be replaced with
acoustical foam.
When setting up a three-dimensional measuring system, it should be setup on an undamaged area. -
Correct Answers Starting in the center section is the correct method.
,What is the plastic Black box in rear of the car? - Correct Answers Vapor Canister
Grinding or squeaking from wheel is a sign of what? - Correct Answers Bad Bearings
The insurance commissioner is responsible for everything except? - Correct Answers Endorsing an
insurance company
How do you tell when a ball joint is bad? - Correct Answers Measure fixed points from knuckle to rotor
What makes the windows go up and down? - Correct Answers Window regulator
What panel needs to get removed is there is damage to the quarter panel? - Correct Answers The
taillight
Actuator - Correct Answers Tells something to do something
Sensor - Correct Answers Take reading and tell when something is wrong
What is Urethane Paint? - Correct Answers Better than acrylic, extremely durable, and resists chipping;
easier to apply
What makes up the body of the vehicle? - Correct Answers Anything that is welded together
Who has the first right to salvage? - Correct Answers The insurer
What components make up a unibody? - Correct Answers Last answer, longest answer on exam
question
What needs to be on an appraisal? - Correct Answers A license number
,The photo of the Buick sedan with a rear fixed axle: - Correct Answers Two wheel alignment
What are the two most common types of engines? - Correct Answers V and inline
What are the two types of vehicle bodies? - Correct Answers Conventional full frame and
Unibody/Unitized construction
What does PCV stand for? - Correct Answers Positive Crankshaft Ventilation
What zones are on a Unibody frame? - Correct Answers Crush zones
What does the PCV Valve do? - Correct Answers It is a passage for gases to escape in a controlled
manner from the crankcase
C Pillar is also known as the - Correct Answers Lock Pillar
What is the A Pillar - Correct Answers Hinge Pillar
What connects to the A Pillar? - Correct Answers The front door hinges, windshield, cowl, and the front
corner of the roof
B Pillar - Correct Answers Center Pillar
2 door car has - Correct Answers A & C Pillar
4 Door car has - Correct Answers A, B, & C Pillars
What device starts the spark plug firing sequence? - Correct Answers Camshaft Sensor
, What is a solenoid value/ starter solenoid? - Correct Answers The park of a car which switches a large
electrical current to the starter motor
What is a MacPherson Strut? - Correct Answers - Front suspension system in newer vehicles
- Single control arm-connects to body directly
- Pros - cheap, simple, lighter
- Cons - only used on unibody vehicles; Taller, no camber gain.
- 3 of the multiple choice answers say 2 arms. Choose the option with 1 arm.
On the picture of the flares with the truck, why don't you refinish the flares? - Correct Answers The
flares come in the color that they are made in.
If there is possible frame damage, what should you write on the estimate? - Correct Answers Setup and
measure
What is the part of the tire that contracts the rim of the wheel? - Correct Answers Bead
How do hood assemblies come? - Correct Answers Welded together, sometimes hinges come with it.
Where is the heater core located? - Correct Answers Under the cowl
How do you repair the tiny holes on the white car's rear bumper? - Correct Answers Lord fuser, plastic
welder
What does the photo of the BMW SUV with the independent suspension need? - Correct Answers
needs a 4 wheel alignment
What dives the floor pan strength? - Correct Answers The Inner rocker panel
What is the EGR Valve? - Correct Answers Exhaust Gas Recirculation- regulates the flow of exhaust gas
into the intake
length condition.
When measuring a unibody vehicle, it is discovered that the left front rail is 111mm from spec in width.
What condition is this? - Correct Answers Width is calculated from the center out, so a value of -111mm
on the left rail shows sway to the right and in toward centerline.
A collision damaged vehicle is discovered to be down in height at opposite end of the center section. -
Correct Answers Twist condition.
When diagnosing the damage to a full frame assembly on a sport utility vehicle, it is determined that the
left side frame rail is higher than the right side frame rail. Technician A says the damaged state is known
as a twist condition. Technician B says a sway condition exists. Who is right? - Correct Answers Tech A.
When a frame rail's relationship to the vehicle centerline is changed, such as pushed either to the left or
right, the condition is known as sway. "Twist" is referred as the condition of the frame when entire
sections are driven higher or lower than the opposite side.
Metal fillers contain different ingredients that provide fillers with special properties. - Correct Answers
Fiberglass offers more resistance to moisture
HSLA - Correct Answers High Strength Low Alloy
When replacing the floor pan in the trunk area, what joint should be used to join the new pan to the
existing floor? - Correct Answers An overlap joint
When acoustical foam is removed during the repair: - Correct Answers It must be replaced with
acoustical foam.
When setting up a three-dimensional measuring system, it should be setup on an undamaged area. -
Correct Answers Starting in the center section is the correct method.
,What is the plastic Black box in rear of the car? - Correct Answers Vapor Canister
Grinding or squeaking from wheel is a sign of what? - Correct Answers Bad Bearings
The insurance commissioner is responsible for everything except? - Correct Answers Endorsing an
insurance company
How do you tell when a ball joint is bad? - Correct Answers Measure fixed points from knuckle to rotor
What makes the windows go up and down? - Correct Answers Window regulator
What panel needs to get removed is there is damage to the quarter panel? - Correct Answers The
taillight
Actuator - Correct Answers Tells something to do something
Sensor - Correct Answers Take reading and tell when something is wrong
What is Urethane Paint? - Correct Answers Better than acrylic, extremely durable, and resists chipping;
easier to apply
What makes up the body of the vehicle? - Correct Answers Anything that is welded together
Who has the first right to salvage? - Correct Answers The insurer
What components make up a unibody? - Correct Answers Last answer, longest answer on exam
question
What needs to be on an appraisal? - Correct Answers A license number
,The photo of the Buick sedan with a rear fixed axle: - Correct Answers Two wheel alignment
What are the two most common types of engines? - Correct Answers V and inline
What are the two types of vehicle bodies? - Correct Answers Conventional full frame and
Unibody/Unitized construction
What does PCV stand for? - Correct Answers Positive Crankshaft Ventilation
What zones are on a Unibody frame? - Correct Answers Crush zones
What does the PCV Valve do? - Correct Answers It is a passage for gases to escape in a controlled
manner from the crankcase
C Pillar is also known as the - Correct Answers Lock Pillar
What is the A Pillar - Correct Answers Hinge Pillar
What connects to the A Pillar? - Correct Answers The front door hinges, windshield, cowl, and the front
corner of the roof
B Pillar - Correct Answers Center Pillar
2 door car has - Correct Answers A & C Pillar
4 Door car has - Correct Answers A, B, & C Pillars
What device starts the spark plug firing sequence? - Correct Answers Camshaft Sensor
, What is a solenoid value/ starter solenoid? - Correct Answers The park of a car which switches a large
electrical current to the starter motor
What is a MacPherson Strut? - Correct Answers - Front suspension system in newer vehicles
- Single control arm-connects to body directly
- Pros - cheap, simple, lighter
- Cons - only used on unibody vehicles; Taller, no camber gain.
- 3 of the multiple choice answers say 2 arms. Choose the option with 1 arm.
On the picture of the flares with the truck, why don't you refinish the flares? - Correct Answers The
flares come in the color that they are made in.
If there is possible frame damage, what should you write on the estimate? - Correct Answers Setup and
measure
What is the part of the tire that contracts the rim of the wheel? - Correct Answers Bead
How do hood assemblies come? - Correct Answers Welded together, sometimes hinges come with it.
Where is the heater core located? - Correct Answers Under the cowl
How do you repair the tiny holes on the white car's rear bumper? - Correct Answers Lord fuser, plastic
welder
What does the photo of the BMW SUV with the independent suspension need? - Correct Answers
needs a 4 wheel alignment
What dives the floor pan strength? - Correct Answers The Inner rocker panel
What is the EGR Valve? - Correct Answers Exhaust Gas Recirculation- regulates the flow of exhaust gas
into the intake
