BMW ASE PREP ASSOCIATE STUDY GUIDE|
COMPLETE SOLUTION | GRADED A+.
Brake Pad Minimum Thickness
Customer Pay
Warranty
CPO - Customer Pay: 3mm
Warranty: 4mm (3.9mm)
CPO: 5 mm
Brake bleed pressure setting (bar): - 2 bar max
- Location of MSDS: - Online
CPO test drive (length and distance): - 20 uninterrupted minutes/ 5 continuous miles
Caliper bleeding with 2 bleed screws - Outer bleeder first, then inner
- Is prescription eye wear valid eye protection in a bmw shop? - no
How do you measure a vehicle wheel base? - Center of front wheel to center of rear
wheel
What does OL reading mean on DVOM? - Open circuit
What can effect starter operation? - Battery cable length, cable diameter, loose
connections, corrosion, high resistance
Brake calipers are seized and the master cylinder cap seal is swollen. What could
cause this? - Oil
- If found swollen, replace all rubber components
What is a refractometer? - - Tool to measure concentration of mixture
What sensor calculates density or volume of air? - MAF (mass air flow) CORRECT
ANSWER
-MAP (manifold absolute pressure) INCORRECT ANSWER
Leaking shock/strut- out of warranty (customer pay situation) - - Replace both
shocks/struts
Bolt sizing example: What is a 9.8? - Grade of bolt/ tensile strength (Higher number =
Stronger)
COMPLETE SOLUTION | GRADED A+.
Brake Pad Minimum Thickness
Customer Pay
Warranty
CPO - Customer Pay: 3mm
Warranty: 4mm (3.9mm)
CPO: 5 mm
Brake bleed pressure setting (bar): - 2 bar max
- Location of MSDS: - Online
CPO test drive (length and distance): - 20 uninterrupted minutes/ 5 continuous miles
Caliper bleeding with 2 bleed screws - Outer bleeder first, then inner
- Is prescription eye wear valid eye protection in a bmw shop? - no
How do you measure a vehicle wheel base? - Center of front wheel to center of rear
wheel
What does OL reading mean on DVOM? - Open circuit
What can effect starter operation? - Battery cable length, cable diameter, loose
connections, corrosion, high resistance
Brake calipers are seized and the master cylinder cap seal is swollen. What could
cause this? - Oil
- If found swollen, replace all rubber components
What is a refractometer? - - Tool to measure concentration of mixture
What sensor calculates density or volume of air? - MAF (mass air flow) CORRECT
ANSWER
-MAP (manifold absolute pressure) INCORRECT ANSWER
Leaking shock/strut- out of warranty (customer pay situation) - - Replace both
shocks/struts
Bolt sizing example: What is a 9.8? - Grade of bolt/ tensile strength (Higher number =
Stronger)
