NCCCO TSS MANITEX EXAM QUESTIONS AND ANSWERS VERIFIED 100% CORRECT

NCCCO TSS MANITEX EXAM QUESTIONS AND ANSWERS VERIFIED 100% CORRECT A crane should always be barricaded within? - ANSWER -The swing radius of the rear of the rotation superstructure counterweight The crane must have a ______ inspection performed both monthly and yearly. This information must be documented by the employer that conducts the inspection. - ANSWER -Periodic Slings should always be marked with a capacity rate in tag. - ANSWER -True The wire rope clip on a wedge socket Should always attached to the _______ Of the Crane. - ANSWER -Dead end It is possible for a crane to be overloaded with no signs of tipping. - ANSWER True In rotation resistant ropes if you have ______ broken wires and six rope diameter or _______ broken wires and 30 rope diameters, the rope must be removed from service. - ANSWER -2,4 In order to operate a mobile crane on a barge, you must have - ANSWER -List and trim capacity chart When lifting a load out of the water, the load will be come ________ When it breaks the surface - ANSWER -Heavier What must be done when operating on a barge? - ANSWER -Attach the crane to the barge Mobile crane is more stable when: - ANSWER -The cranes leverage is greater than the load leverage As a crane tips the loads leverage - ANSWER -Increases What should be done if a crane has a cracked windshield? - ANSWER -Continue to operate if it causes no visible distortion On a truck crane or all-terrain crane, the strongest quadrant is normally the? - ANSWER -Rear If boom links are in between on the load chart you should always: - ANSWER Use lowest capacity of the next longer or shorter boom length If radius is in between on load chart, you should use: - ANSWER -Next longer radius If the boom angle is in between on the load chart, you should: - ANSWER -Use next lower boom angle Net capacity equals: - ANSWER -Gross capacity minus all deductions When is the Hoist rope consider a deduction? - ANSWER -All the above A Crane must be within _____ of level for the load chart to apply. - ANSWER 1% Traveling down a hill with a load will _____ radius - ANSWER -Increase During a pick and carry Which of the following would apply? - ANSWER -Boom in line with direction of travel According to 1926.1431, at what windspeed must a qualified person be consulted? - ANSWER -20 miles an hour Sudden stops dynamic Loading can cause the load to________ - ANSWER Increase For duty cycle operations like pouring concrete, hanging steel, etc. most manufacturers usually downrate the crane________. - ANSWER -20% A _________Inspection is the responsibility of the crane operator. - ANSWER Frequent Hoist lines should be replaced when there is more than a _____ Reduction in the normal diameter of the rope. - ANSWER -5% A tagline is required to handle a load when? - ANSWER -When needed to control the load Where is the best place to level a crane? - ANSWER -Upper works What are the industry standards that cover mobile cranes? - ANSWER -OSHA 1926.1400 and ASME B30.5 In rotation resistant rope, if you have _____ broken wires and six rope diameter and ______ In 30 rope diameters, the rope must be removed from service. - ANSWER -2,4 And standard rope if you have _____ broken wires randomly distributed in a rope lay and ________ broken wires in a strand in a Lay It must be removed from service. - ANSWER -6,3 When picking off the main boom, what determines the unused jib deduction? - ANSWER -The effective weight of the jib Setting up a mobile crane with long boom on uneven ground, what support condition should be considered? - ANSWER -Keeping it 90° between cylinder rod and the pad How should the tires be positioned when setting up a crane on outriggers? - ANSWER -All tires relieved of the cranes weight or preferably off the ground