Ca Smog Check Inspector Training Final Review (Part 2)

Only smoke emitted from the crankcase vent hoses (PCV System) during the inspection for visible smoke. - Answer- What constitutes a failure of the crankcase portion of the visible smoke test? 10 Seconds - Answer- How long should the tailpipe and crankcase be observed during the idle portion of the Visible Smoke Test? All hybrid vehicles - Answer- Which vehicles are not subject to a Visible Smoke Test? More than three seconds. - Answer- How long must smoke linger in order to constitute a Visible Smoke Test failure for a diesel vehicle? tailpipe, LPFET - Answer- Diesel vehicles are not subject to __________ or _____________ inspections Determine if either the hood or engine has been changed. - Answer- What action should be taken if it is determined that the underhood label does not match the engine? Consult the ECS manual to determine required equipment and timing settings. - Answer- If it is determined that a hood has been replaced and the underhood label is missing or incorrect for the vehicle, what action should be taken? Refer the vehicle to the referee for certification. - Answer- If it is determined that an engine has been changed and the vehicle is not equipped with a BAR Referee Label, what action should be taken? $650 - Answer- What is the minimum amount a consumer must spend before they become eligible for a Repair Cost Waiver? $500, minus a $20 deductible - Answer- The Consumer Assistance Program will pay a maximum of __________ toward the cost of an eligible repair. Stuck EGR pintle, plugged EGR passage - Answer- During a functional test of the EGR system, the RPM does not change when vacuum is applied. What are some possible causes? Center the vehicle on the dyno. - Answer- Prior to restraining the vehicle, what should the technician do? The BAR 97 EIS will lock out, requiring a service call for repair. It is illegal for technician to access the internal portion of the machine? - Answer- If the technician attempts to access the BAR97