ICC VAPOR RECOVERY VT EXAMINATION
TEST 2026 QUESTIONS WITH ANSWERS
GRADED A+
◉ Number of open valves on the clean air separator: Answer: One
◉ You must be CERTIFIED by Healy to re-connect a Healy breakaway,
True or False? Answer: False
◉ The type of pressure gauge is recommended to test Healy Vac.
Answer: SYSA gauge measuring 0-100 WC
◉ On new construction, after July 1, 2004, Can you install an in-ground
Spill Bucket? Answer: YES-When Piping is monitored and with VAC
◉ According to Executive Order 201 - Healy P/V Valve should be
torqued at. Answer: 20-50 ft-lbs
◉ For a fire to burn, these (3) three primary elements must exist:
Answer: Fuel, Oxygen, Ignition Source
,◉ When working with Electrical - Lock Out Tag Out procedures are
under these guidelines. Answer: CAL-OSHA
◉ Organization that certifies vapor recovery systems. Answer: CARB or
ARB
◉ According to RP 500, a level II technician may NOT inspect this part.
Answer: Replace VP 1000 Healy Pump
◉ where hanging hardware repairs must be tracked. Answer: GDF
maintenance log
◉ approved sealant when assembling a Phil-Tite Drop Tube. Answer:
JB-Kwik
◉ Material direct bury OPW container sleeve shall be made of. Answer:
Stainless steel
◉ What P/V vent cap shall be tightened to. Answer: 20-50 ft lbs
◉ From dispenser to manifold - 2" diameter vapor piping ( 2" ID) and
From manifold to tank - 3" diameter vapor piping (3" ID). Answer:
Vapor piping
, ◉ What is the maximum run for vapor piping? Answer: No maximum
run
◉ How you know a nozzle spout is bad. Answer: 'BAD O-rinqs
◉ According to PEI RP 300, on a balance Stage II vapor recovery
system nozzle, Vapors typically flow in what direction of the coaxial
hose? Answer: The outside pathway
◉ What is the maximum allowable number of P/V caps allowed on a
UST fuel system? Answer: One
◉ On a Healy Air Separator, there are four Ball Valves, the following
shall be observed? Answer: One valve shall remain open on top
◉ The Pressure settings for the UST Vent Cap is. Answer: .0+- 0.5inches
H2O Negative Pressure 1,0+-2.0 inches H2O Positive Pressure
◉ Given that in a balance Stage II vapor recovery system, the nozzle is
equipped with a flexible nozzle bellows that seals around the automobile
fill pipe. This is how vapors will typically flow. Answer: From the
outside pathway of the coaxial hose
◉ The Healy 1301 flow limiter shall be used when the flow rate exceeds
this. Answer: 10.0 GPM
TEST 2026 QUESTIONS WITH ANSWERS
GRADED A+
◉ Number of open valves on the clean air separator: Answer: One
◉ You must be CERTIFIED by Healy to re-connect a Healy breakaway,
True or False? Answer: False
◉ The type of pressure gauge is recommended to test Healy Vac.
Answer: SYSA gauge measuring 0-100 WC
◉ On new construction, after July 1, 2004, Can you install an in-ground
Spill Bucket? Answer: YES-When Piping is monitored and with VAC
◉ According to Executive Order 201 - Healy P/V Valve should be
torqued at. Answer: 20-50 ft-lbs
◉ For a fire to burn, these (3) three primary elements must exist:
Answer: Fuel, Oxygen, Ignition Source
,◉ When working with Electrical - Lock Out Tag Out procedures are
under these guidelines. Answer: CAL-OSHA
◉ Organization that certifies vapor recovery systems. Answer: CARB or
ARB
◉ According to RP 500, a level II technician may NOT inspect this part.
Answer: Replace VP 1000 Healy Pump
◉ where hanging hardware repairs must be tracked. Answer: GDF
maintenance log
◉ approved sealant when assembling a Phil-Tite Drop Tube. Answer:
JB-Kwik
◉ Material direct bury OPW container sleeve shall be made of. Answer:
Stainless steel
◉ What P/V vent cap shall be tightened to. Answer: 20-50 ft lbs
◉ From dispenser to manifold - 2" diameter vapor piping ( 2" ID) and
From manifold to tank - 3" diameter vapor piping (3" ID). Answer:
Vapor piping
, ◉ What is the maximum run for vapor piping? Answer: No maximum
run
◉ How you know a nozzle spout is bad. Answer: 'BAD O-rinqs
◉ According to PEI RP 300, on a balance Stage II vapor recovery
system nozzle, Vapors typically flow in what direction of the coaxial
hose? Answer: The outside pathway
◉ What is the maximum allowable number of P/V caps allowed on a
UST fuel system? Answer: One
◉ On a Healy Air Separator, there are four Ball Valves, the following
shall be observed? Answer: One valve shall remain open on top
◉ The Pressure settings for the UST Vent Cap is. Answer: .0+- 0.5inches
H2O Negative Pressure 1,0+-2.0 inches H2O Positive Pressure
◉ Given that in a balance Stage II vapor recovery system, the nozzle is
equipped with a flexible nozzle bellows that seals around the automobile
fill pipe. This is how vapors will typically flow. Answer: From the
outside pathway of the coaxial hose
◉ The Healy 1301 flow limiter shall be used when the flow rate exceeds
this. Answer: 10.0 GPM
