1|Page
ASP FINAL EXAM 2 VERSIONS | COMPLETE TEST BANK |
FREQUENTLY TESTED QUESTIONS AND ANSWERS |
EXPERT VERIFIED STUDY GUIDE FOR GUARANTEED PASS
GRADED || A+ ||
"
What is most correct concerning mishaps involving industrial robots? -
ANSWER: Most accidents occur within the primary zone of the robot
What is most correct concerning NIOSH? - ANSWER-NIOSH reports to
HHS
What is most essential consideration in developing a safety training
program? - ANSWER-Training objectives
What is most significant when evaluating equipment maintenance operating
procedures? - ANSWER-Ensuring that the machine energy is zero and will
remain so during maintenance
What is necessary when hearing protection is first provided to employees?
- ANSWER: Employees should be shown how to use the hearing protection
and when to use it.
What is not a basic element of a contract? - ANSWER-Monetary duty
What is not a characteristic of a cyclone air cleaner? - ANSWER-Remove
all dusts of health importance
What is not a common redundant design philosophy? - ANSWER-Derating
What is not a communication barrier? - ANSWER-Negative reinforcement
What is not a duty of a central safety committee? - ANSWER-Approving
purchase requests for safety equipment
What is not a general design factor that is normally considered in system
safety work? - ANSWER-Cost-benefit ratio
2025/2026
,2|Page
What is not a purpose for displaying safety posters? - ANSWER-As a
substitute for management support
What is not a reportable DOT accident? - ANSWER-Injury not requiring
medical response
What is not a required element of a respirator maintenance program? -
ANSWER-Selection and purchase
What is not a symptom of carpal tunnel syndrome? - ANSWER-Numbness
in the little finger
What is not always required from a company that received an OSHA
citation? - ANSWER-Not always required to retrain all employees
What is not an advantage of the lecture presentation? - ANSWER-There is
only limited audience participation
What is not an expected outcome of group training? - ANSWER-Gains
skills
What is not considered a major type of machine guard within general
industry? - ANSWER-Swing away
What is not included in the ten basic principles of safety? - ANSWER-
Safety management should be treated separately and different from other
company management.
What is not true about Failure Modes and Effects Analysis (FMEA) -
ANSWER-FMEA does not identify multiple failures, human factors and
interfaces
What is not true concerning carbon monoxide? - ANSWER-"· The current
TLV for CO is 1500ppm
IDLH for CO according to NIOSH guide is 1500ppm
"
2025/2026
,3|Page
What is not true concerning establishment of management goals for the
occupational safety and health program? - ANSWER-Management goals
should be published
What is not true concerning Metal Fume Fever? - ANSWER-"· MFF is a
permanent condition, which is compensable thru the workers compensation
system in all states.
Recovery is complete within two days
"
What is not true concerning OSHAS standard on benzene? - ANSWER-
"OSHA 1910.1028
Employees requiring medical examination will be afforded an examination
within 30 days of initial assignment.
The initial examination should be conducted at or before the initial
assignment
"
What is not true concerning parking of a commercial vehicle transporting
hazardous materials (explosives "A" or explosives "B")? - ANSWER-"The
driver can have someone watch the vehicle when parked on a public street
You may let someone else watch it for you:
On the shippers property
On the carriers property
On the consignees property
Refer to 49 CFR part 397.5
"
What is not true concerning the OSHA regulations on exposure to
cadmium? - ANSWER-"See OSHA 1910.1027
Exposures over the PEL requires biological monitoring, one acceptable
method would be a test for hippuric acid in the urine at the end of the
shift??
2025/2026
, 4|Page
"
What is not true when comparing the capabilities of a computer and
humans? - ANSWER-Computers are better at following random and
variable strategy
What is one characteristic of system safety? - ANSWER-It is done before
mishaps occur
What is required in order to make valid decisions? - ANSWER-Listening
What is required when performing welding operations in a petroleum
facility? - ANSWER-An approved hot work permit
What is siderosis? - ANSWER-Siderosis is an adverse condition developed
in lungs (similar to asbestosis) as a result inhalation of metal fumes or dust
generated in most welding and grinding operations. Also associated with
fibrous materials, as well as with mining and processing of iron ore.
What is static accumulation associated with aircraft fueling operations best
minimized by? - ANSWER-Grounding airplane, grounding fueler, bonding
both
What is the audible range for an average young person with unimpaired
hearing? - ANSWER-Between 20-20,000Hz
What is the best description of a chemical that causes damage to a fetus? -
ANSWER-Teratogen
What is the best example of a leading indicator of safety, health and
environmental performance? - ANSWER-Number of corrective actions
closed from incident reports-a leading indicator can help to predict safety
performance.
What is the best indicator of training effectiveness? - ANSWER-Increase in
effectiveness of job performance
What is the best inside stairwell design? - ANSWER-Smoke proof tower
with pressurized stair tower
2025/2026
ASP FINAL EXAM 2 VERSIONS | COMPLETE TEST BANK |
FREQUENTLY TESTED QUESTIONS AND ANSWERS |
EXPERT VERIFIED STUDY GUIDE FOR GUARANTEED PASS
GRADED || A+ ||
"
What is most correct concerning mishaps involving industrial robots? -
ANSWER: Most accidents occur within the primary zone of the robot
What is most correct concerning NIOSH? - ANSWER-NIOSH reports to
HHS
What is most essential consideration in developing a safety training
program? - ANSWER-Training objectives
What is most significant when evaluating equipment maintenance operating
procedures? - ANSWER-Ensuring that the machine energy is zero and will
remain so during maintenance
What is necessary when hearing protection is first provided to employees?
- ANSWER: Employees should be shown how to use the hearing protection
and when to use it.
What is not a basic element of a contract? - ANSWER-Monetary duty
What is not a characteristic of a cyclone air cleaner? - ANSWER-Remove
all dusts of health importance
What is not a common redundant design philosophy? - ANSWER-Derating
What is not a communication barrier? - ANSWER-Negative reinforcement
What is not a duty of a central safety committee? - ANSWER-Approving
purchase requests for safety equipment
What is not a general design factor that is normally considered in system
safety work? - ANSWER-Cost-benefit ratio
2025/2026
,2|Page
What is not a purpose for displaying safety posters? - ANSWER-As a
substitute for management support
What is not a reportable DOT accident? - ANSWER-Injury not requiring
medical response
What is not a required element of a respirator maintenance program? -
ANSWER-Selection and purchase
What is not a symptom of carpal tunnel syndrome? - ANSWER-Numbness
in the little finger
What is not always required from a company that received an OSHA
citation? - ANSWER-Not always required to retrain all employees
What is not an advantage of the lecture presentation? - ANSWER-There is
only limited audience participation
What is not an expected outcome of group training? - ANSWER-Gains
skills
What is not considered a major type of machine guard within general
industry? - ANSWER-Swing away
What is not included in the ten basic principles of safety? - ANSWER-
Safety management should be treated separately and different from other
company management.
What is not true about Failure Modes and Effects Analysis (FMEA) -
ANSWER-FMEA does not identify multiple failures, human factors and
interfaces
What is not true concerning carbon monoxide? - ANSWER-"· The current
TLV for CO is 1500ppm
IDLH for CO according to NIOSH guide is 1500ppm
"
2025/2026
,3|Page
What is not true concerning establishment of management goals for the
occupational safety and health program? - ANSWER-Management goals
should be published
What is not true concerning Metal Fume Fever? - ANSWER-"· MFF is a
permanent condition, which is compensable thru the workers compensation
system in all states.
Recovery is complete within two days
"
What is not true concerning OSHAS standard on benzene? - ANSWER-
"OSHA 1910.1028
Employees requiring medical examination will be afforded an examination
within 30 days of initial assignment.
The initial examination should be conducted at or before the initial
assignment
"
What is not true concerning parking of a commercial vehicle transporting
hazardous materials (explosives "A" or explosives "B")? - ANSWER-"The
driver can have someone watch the vehicle when parked on a public street
You may let someone else watch it for you:
On the shippers property
On the carriers property
On the consignees property
Refer to 49 CFR part 397.5
"
What is not true concerning the OSHA regulations on exposure to
cadmium? - ANSWER-"See OSHA 1910.1027
Exposures over the PEL requires biological monitoring, one acceptable
method would be a test for hippuric acid in the urine at the end of the
shift??
2025/2026
, 4|Page
"
What is not true when comparing the capabilities of a computer and
humans? - ANSWER-Computers are better at following random and
variable strategy
What is one characteristic of system safety? - ANSWER-It is done before
mishaps occur
What is required in order to make valid decisions? - ANSWER-Listening
What is required when performing welding operations in a petroleum
facility? - ANSWER-An approved hot work permit
What is siderosis? - ANSWER-Siderosis is an adverse condition developed
in lungs (similar to asbestosis) as a result inhalation of metal fumes or dust
generated in most welding and grinding operations. Also associated with
fibrous materials, as well as with mining and processing of iron ore.
What is static accumulation associated with aircraft fueling operations best
minimized by? - ANSWER-Grounding airplane, grounding fueler, bonding
both
What is the audible range for an average young person with unimpaired
hearing? - ANSWER-Between 20-20,000Hz
What is the best description of a chemical that causes damage to a fetus? -
ANSWER-Teratogen
What is the best example of a leading indicator of safety, health and
environmental performance? - ANSWER-Number of corrective actions
closed from incident reports-a leading indicator can help to predict safety
performance.
What is the best indicator of training effectiveness? - ANSWER-Increase in
effectiveness of job performance
What is the best inside stairwell design? - ANSWER-Smoke proof tower
with pressurized stair tower
2025/2026
