MASSACHUSETTS OIL BURNER STUDY GUIDE EXAM
QUESTIONS & 100% CORRECT ANSWERS (VERIFIED)
What |is |the |voltage |found |at |the |TT |terminals
Correct |Answer: | 24 |volts
What |are |the |8 |steps |of |a |no |heat |call
Correct |Answer: | 1 |talk |to |customer |2 |check |tt.3 |check |to |make |sure |an |emergency
| switch |is |on |4check |to |make |sure |there |is |oil |in |the |tank |5 |check |to |make |sure |the |main
| power |going |to |the |unit |is |on |six |check |to |make |sure |that |tank |shut |off |valve |is |open |7
| know |whether |the |tank |is |located |above |or |below |the |burner |I |know |the |type |and |style |of
| the |system |that |is |being |used |on |a |one |or |two |pipe |system
What |is |a |cad |cell
Correct |Answer: | A |device |containing |condominium |sulfide |used |to |prove |the |flame |in |oil
| burner |furnace
How |much |air |is |needed |to |burn |a |gallon |of |number |2 |fuel |oil |and |why.
,Correct |Answer: | In |2015 |most |oil |burners |are |set |up |to |burn |with |approximately |50%
| excess |air |because |it |would |be |dangerous |to |set |up |a |burner |for |exactly |the |correct
| amount |of |air
What |is |the |term |InStep |mean
Correct |Answer: | The |stack |relay |is |operating |correctly
What |is |normal |pump |pressure
Correct |Answer: | 100 |PSI
How |is |combustion |achieved
Correct |Answer: | Atomization, |air, |ignition.
What |is |primary |air |and |secondary |air
Correct |Answer: | Primary |air, |air |that |is |introduced |to |a |furnace |burner |before |the
| combustion |process |has |taken |place. |secondary |air, |air |that |is |introduced |to |the |furnace
| after |combustion |has |taken |place |and |that |supports |combustion
How |should |an |oil |tank |be |supported
Correct |Answer: | It |shall |be |secured |attached |to |a |non-combustible |supports
What |is |the |wire |gauge |use |an |oil |burner |circuits
Correct |Answer: | 14 |gauge |15 |amp |fuse
, How |is |an |oil |burner |wired
Correct |Answer: | Shall |be |wired |on |its |own |circuit. |All |protective |control |and |emergency
devices |shall |be |series |connected |in |the |grounded |line |conductors. |all |the |electrical
|
wiring |shall |be |in |accordance |with |527 |CMR |12.00 |Massachusetts |electrical |code
|
What |size |vent |pipe |is |required |with |a |2 |inch |fill |pipe
Correct |Answer: | A |fill |pipe |shall |not |be |greater |than |the |vent |pipe. |The |minimum |the |fill |pipe
| in |the |state |of |Massachusetts |is |one |and |one |quarter |inch.
Explain |interrupted |ignition
Correct |Answer: | the |ignition |Transformer |drops |out |of |the |circuit |once |a |flame |is |established
What |are |the |elements |are |found |in |fuel |oil |number |2
Correct |Answer: | Carbon |hydrogen |oxygen |and |hydrocarbons
What |is |a |BTU
Correct |Answer: | A |British |thermal |unit |is |the |amount |of |heat |needed |to |raise |one |pound
| of |water |1 |degree |Fahrenheit
How |many |BTUs |are |in |one |gallon |number |2 |fuel |oil
QUESTIONS & 100% CORRECT ANSWERS (VERIFIED)
What |is |the |voltage |found |at |the |TT |terminals
Correct |Answer: | 24 |volts
What |are |the |8 |steps |of |a |no |heat |call
Correct |Answer: | 1 |talk |to |customer |2 |check |tt.3 |check |to |make |sure |an |emergency
| switch |is |on |4check |to |make |sure |there |is |oil |in |the |tank |5 |check |to |make |sure |the |main
| power |going |to |the |unit |is |on |six |check |to |make |sure |that |tank |shut |off |valve |is |open |7
| know |whether |the |tank |is |located |above |or |below |the |burner |I |know |the |type |and |style |of
| the |system |that |is |being |used |on |a |one |or |two |pipe |system
What |is |a |cad |cell
Correct |Answer: | A |device |containing |condominium |sulfide |used |to |prove |the |flame |in |oil
| burner |furnace
How |much |air |is |needed |to |burn |a |gallon |of |number |2 |fuel |oil |and |why.
,Correct |Answer: | In |2015 |most |oil |burners |are |set |up |to |burn |with |approximately |50%
| excess |air |because |it |would |be |dangerous |to |set |up |a |burner |for |exactly |the |correct
| amount |of |air
What |is |the |term |InStep |mean
Correct |Answer: | The |stack |relay |is |operating |correctly
What |is |normal |pump |pressure
Correct |Answer: | 100 |PSI
How |is |combustion |achieved
Correct |Answer: | Atomization, |air, |ignition.
What |is |primary |air |and |secondary |air
Correct |Answer: | Primary |air, |air |that |is |introduced |to |a |furnace |burner |before |the
| combustion |process |has |taken |place. |secondary |air, |air |that |is |introduced |to |the |furnace
| after |combustion |has |taken |place |and |that |supports |combustion
How |should |an |oil |tank |be |supported
Correct |Answer: | It |shall |be |secured |attached |to |a |non-combustible |supports
What |is |the |wire |gauge |use |an |oil |burner |circuits
Correct |Answer: | 14 |gauge |15 |amp |fuse
, How |is |an |oil |burner |wired
Correct |Answer: | Shall |be |wired |on |its |own |circuit. |All |protective |control |and |emergency
devices |shall |be |series |connected |in |the |grounded |line |conductors. |all |the |electrical
|
wiring |shall |be |in |accordance |with |527 |CMR |12.00 |Massachusetts |electrical |code
|
What |size |vent |pipe |is |required |with |a |2 |inch |fill |pipe
Correct |Answer: | A |fill |pipe |shall |not |be |greater |than |the |vent |pipe. |The |minimum |the |fill |pipe
| in |the |state |of |Massachusetts |is |one |and |one |quarter |inch.
Explain |interrupted |ignition
Correct |Answer: | the |ignition |Transformer |drops |out |of |the |circuit |once |a |flame |is |established
What |are |the |elements |are |found |in |fuel |oil |number |2
Correct |Answer: | Carbon |hydrogen |oxygen |and |hydrocarbons
What |is |a |BTU
Correct |Answer: | A |British |thermal |unit |is |the |amount |of |heat |needed |to |raise |one |pound
| of |water |1 |degree |Fahrenheit
How |many |BTUs |are |in |one |gallon |number |2 |fuel |oil
